The Ye Tuo ultra pure water hydrogen generator has low operating noise and operates quietly in daily work, making it very suitable for placement and use on regular laboratory countertops.
This model does not have an air compressor structure, and the source of overall noise is only the built-in cooling fan. There is no periodic vibration noise caused by compressor start stop. Under normal and stable gas production conditions, the equipment noise is about 42-48dB (A), which is equivalent to the volume of soft indoor conversations and much lower than air generators and hydrogen air integrated machines with compressors.
Noise related characteristics
1. Load following design to further reduce sustained noise
The device has intelligent gas tracking function. When the chromatographic instrument does not require a large amount of hydrogen, the electrolysis power will automatically decrease and the fan will run at low speed; The fan runs at full speed only when there is continuous high flow of air to avoid long-term high noise operation.
2. Optimization of overall vibration reduction to reduce resonance noise
The internal components of the chassis are securely assembled, and the bottom is equipped with sliding shock-absorbing foot pads to weaken the vibration transmission between the body and the experimental table, resulting in additional noise caused by resonance.
3. Visual comparison with similar devices
-Compared to hydrogen air integrated machines and nitrogen generators (with built-in compressors): significantly lower noise;
-Compared to ordinary alkaline electrolysis hydrogen generators: optimized fan airflow matching and better wind noise control;
-Wan will not cause acoustic interference to precision instruments such as scales and spectra.
Practical usage suggestions
1. Reserve ≥ 15cm of heat dissipation space behind and on both sides of the equipment to prevent air duct blockage from causing high load operation and noise increase of the fan;
2. Choose a flat and stable tabletop for placement, avoid hanging or stacking, and prevent vibration amplification;
3. If there is obvious buzzing or abnormal noise, it is mostly due to dust accumulation and loose fixing of the fan, which is a routine maintainable fault and not an inherent problem of the equipment.
Summary
Overall, the Ye Tuo ultra pure water hydrogen generator belongs to low-noise gas source equipment, and long-term continuous operation will not cause laboratory noise problems. It is suitable for scenarios such as chromatographic analysis laboratories, research offices, teaching laboratories, etc. that require environmental quietness.
